HVAC & Electrical Pricing Guide — Orange County 2026
Complete reference: AC repair, panel upgrades, EV chargers, furnace, ductless, gas line. Honest mid-market pricing from a dual-licensed contractor.
Call 714-499-6656
Important: All prices below are typical Orange County 2026 ranges from
Aerosphere Electric. Your actual price depends on your home, equipment condition, accessibility, permit requirements, and utility coordination. We provide free written estimates — call
714-499-6656.
Service Calls & Diagnostics
| Service | Cost | Notes |
|---|
| Standard diagnostic / service call | $89 | Waived if work is authorized |
| Emergency / after-hours surcharge | +$50 | Added to standard rate |
| Holiday surcharge (Thanksgiving, Christmas, etc.) | +$75-$150 | Major holidays only |
| Free estimate (installations only) | $0 | Written estimate for new installs |
AC Repair (Orange County 2026)
| Service | Typical Cost | Notes |
|---|
| Capacitor replacement | $150 – $450 | Most common AC repair |
| Contactor replacement | $200 – $400 | |
| Refrigerant recharge (R-410A) | $250 – $700 | Plus leak repair if needed |
| Refrigerant leak repair | $400 – $1,500 | Depends on location |
| Condenser fan motor | $300 – $650 | |
| Blower motor replacement | $300 – $650 | |
| Evaporator coil replacement | $900 – $2,500 | |
| Compressor replacement | $1,200 – $2,800 | Often replacement of unit recommended |
| Thermostat install (programmable) | $150 – $300 | |
| Smart thermostat install (Nest, Ecobee) | $250 – $500 | May qualify for rebate |
AC Installation (Orange County 2026)
| System Size | Typical Cost | Best For |
|---|
| 2-ton central AC | $5,500 – $8,500 | Up to 1,200 sq ft |
| 3-ton central AC | $6,500 – $10,500 | 1,200 – 1,800 sq ft |
| 4-ton central AC | $8,000 – $13,000 | 1,800 – 2,800 sq ft |
| 5-ton central AC | $9,500 – $15,000 | 2,800 – 4,000 sq ft |
| Premium variable-speed (Trane XV20i, Lennox SL28XCV) | +25-40% | Maximum efficiency |
| Heat pump system (3-4 ton) | $6,500 – $13,500 | Replaces both AC + furnace |
Ductless Mini-Splits (Orange County 2026)
| Configuration | Typical Cost | Notes |
|---|
| Single-zone (one room) | $3,500 – $6,500 | Goodman/Mr. Cool entry vs. Mitsubishi premium |
| Two-zone | $5,500 – $8,500 | |
| Three-zone | $7,500 – $10,500 | |
| Four-zone | $9,500 – $12,000 | |
| Mitsubishi Hyper-Heat H2i premium | +15-25% | Best cold-weather + warranty |
Furnace (Orange County 2026)
| Service | Typical Cost | Notes |
|---|
| Furnace tune-up | $89 – $149 | Annual maintenance |
| Ignitor replacement | $200 – $400 | Most common furnace repair |
| Flame sensor replacement | $150 – $350 | |
| Gas valve replacement | $400 – $900 | |
| Blower motor replacement | $300 – $650 | |
| Heat exchanger replacement | $1,500 – $3,500 | Usually replace furnace instead |
| Gas furnace 80% AFUE install | $3,500 – $5,500 | Standard efficiency |
| Gas furnace 96% AFUE install | $4,500 – $7,500 | High efficiency, rebate eligible |
| Modulating high-efficiency furnace | $6,500 – $8,500 | Premium tier |
Electrical Panel Upgrades (Orange County 2026)
| Service | Typical Cost | Notes |
|---|
| 100A to 200A upgrade | $1,800 – $3,500 | Most common upgrade |
| 200A new install | $2,500 – $4,500 | |
| 200A + grounding + meter work | $3,500 – $5,500 | Full service entrance |
| 320A or 400A service | $4,500 – $7,000 | Multi-EV, all-electric homes |
| Panel replacement (existing amperage) | $1,500 – $2,800 | FPE / Zinsco swap |
| Sub-panel install | $850 – $2,200 | Garage, ADU, workshop |
| Service | Typical Cost | Notes |
|---|
| Tesla Wall Connector (existing 240V circuit) | $600 – $1,200 | Existing circuit reused |
| Tesla Wall Connector + new 240V circuit | $1,200 – $2,500 | Most common |
| NEMA 14-50 outlet install | $500 – $1,500 | For portable charger |
| Long-run install (over 75 feet) | $2,000 – $3,500 | Garage far from panel |
| Combined panel upgrade + EV charger | $3,000 – $6,500 | When panel is at capacity |
| ChargePoint, Wallbox, JuiceBox install | $700 – $2,800 | Similar to Tesla pricing |
| Service | Typical Cost | Notes |
|---|
| Whole-home rewiring | $8,000 – $25,000 | Depends on home size + access |
| Smart thermostat install | $250 – $500 | Nest, Ecobee, Honeywell |
| Ceiling fan install (new wiring) | $250 – $650 | |
| Recessed lighting (per fixture) | $95 – $200 | Includes fixture + labor |
| Outlet relocation / addition | $150 – $350 | Per outlet |
| GFCI outlet install | $125 – $250 | |
| Whole-home surge protector | $350 – $750 | Panel-mounted |
| Hard-wired smoke + CO detector | $175 – $400 | Per detector |
Gas Line Services (Orange County 2026)
| Service | Typical Cost | Notes |
|---|
| Gas leak detection | $150 – $400 | Applied to repair |
| Section repair (above ground) | $300 – $700 | |
| Section repair (buried) | $600 – $1,500 | Includes excavation |
| Joint / fitting repair | $250 – $500 | Most common |
| Full residential gas line replacement | $1,800 – $4,500 | Whole-home, ~50-100 ft |
| New gas line for pool heater | $800 – $2,200 | |
| New gas line for BBQ | $650 – $1,400 | |
| Gas line for tankless water heater | $500 – $1,200 | |
| Gas line for whole-home generator | $1,200 – $2,800 | |
Maintenance Plans (Orange County 2026)
| Plan | Annual Cost | Includes |
|---|
| Silver Plan | ~$149/yr | 1 annual tune-up, priority scheduling, 10% parts discount |
| Gold Plan | ~$249/yr | 2 tune-ups, priority emergency dispatch, 15% parts discount, no diagnostic fees |
Labor Rates Reference
| Type of Work | Hourly Rate |
|---|
| Standard electrical labor | $125 – $185/hr |
| HVAC repair labor | $135 – $195/hr |
| Master electrician work | $185 – $250/hr |
| Apprentice work (supervised) | $85 – $125/hr |
| Emergency / after-hours | $175 – $250/hr |
Most repairs are flat-rate quoted. Aerosphere Electric does not bill hourly for most repairs — we provide a flat-rate written quote based on the diagnostic. Hourly rates apply only on T&M (time and materials) projects with your prior agreement.
Financing Available
Aerosphere Electric offers 0% APR financing through approved lenders for projects over $1,000. Common terms: 6, 12, 18, or 24 months interest-free. Application takes 5 minutes online. Approved-credit dependent.
Get a Free Written Estimate
Pricing above is typical. Your actual price depends on your specific situation. Free estimates on all installations.
Call 714-499-6656
Related Pages
See complete knowledge base, contractor comparison guide, HVAC services, electrical services, or financing options.